Gil Mikro-San 15 Gallon
Gil Mikro-San 15 Gallon
GIL MIKRO-SAN is a non-iodine blended acid sanitizer for C.I.P. and C.O.P. systems, Tanks and Backflush systems. Gil Mikro-San Concentrated low-foaming acid sanitizer for CIP, COP and circulation applications. Sanitizes food and dairy processing equipment while removing and preventing the buildup of mineral deposits.
CORROSIVE. Causes eye irreversible damage or skin burns. Harmful if swallowed or absorbed through skin or inhaled. Do not get in eyes, on skin or on clothing. Avoid breathing vapor or spray mist. Wash hands before eating, drinking, chewing gum, using tobacco or using the toilet. Remove contaminated clothing and wash clothing before reuse.
Personal Protective Equipment (PPE) Applicator and handlers must wear Coveralls over long sleeved shirt and long pants, socks and chemical-resistant footwear, goggles or face shield and chemical-resistant gloves (such as barrier laminate, butyl rubber, nitrile rubber, PV or viton.)
PHYSICAL CHEMICAL HAZARDS Mix only with water following label directions. Do not mix with chlorinated cleaners or sanitizers. Toxic chlorine gas will be formed. Contact with soft metals may generate hydrogen gas.
ENVIRONMENTAL HAZARDS This product is toxic to fish. Keep out of lakes, ponds or streams. Do not contaminate water by cleaning of equipment or disposal of wastes. Do not discharge effluent containing this product into lakes, streams, ponds, estuaries, oceans or other waters unless in accordance with the requirements of a National Pollutant Discharge Elimination System (NPDES) permit and the permitting authority has been notified in writing prior to discharge. Do not discharge effluent containing this product to sewer systems without previously notifying the local sewage treatment plant authority. For guidance contact your State Water Board or Regional Office of the EPA.
FOOD PROCESSING AND DAIRY EQUIPMENT: Remove gross food particles and soil by a pre-flush or pre-scrape and when necessary, pre-soak treatment. Clean all surfaces with an appropriate chlorinated alkaline cleaner, followed by a potable water rinse prior to the application of the sanitizing solution. Sanitize equipment prior to use with a solution of 1 ounce Gil Mikro-San per 6 gallons of water, to provide 90 ppm of decanoic and nonanoic acid. Circulate sanitizing solution through CIP or COP systems for a minimum of 2 minutes contact time. Sanitizing solution must have a pH of 4 or below. Adequately drain solution. For mechanical operations, the prepared use solution may not be re-used for sanitizing, but may be reused for other purposes such as cleaning. For manual operations, fresh sanitizing solution should be prepared daily or more often if the solution becomes dirty or soiled. Follow state and local Health Department regulations for cleaning and sanitizing food processing and dairy equipment. Regular use of Gil Mikro-San will prevent formation of milkstone and mineralstone on food contact surfaces.
DIRECTIONS FOR USE It is a violation of Federal Law to use this product in a manner inconsistent with its labeling On pre-cleaned food contact surfaces Gil Mikro-San is effective against Salmonella enterica, Listeria monocytogenes and Escherichia coli, 0157:H7, Hemorrhagic.
IF IN EYES: Hold eye open and rinse slowly and gently with water for 15-20 minutes. Remove contact lenses, if present, after first 5 minutes. Then continue rinsing. Call a Poison Control Center or doctor for treatment advice.
IF ON SKIN: Take off contaminated clothing. Rinse skin immediately with plenty of water for 15-20 minutes. Call a Poison Control Center or doctor for treatment advice.
IF SWALLOWED: Call a Poison Control Center or doctor for treatment advice. Have person sip a glass of water if able to swallow. Do not induce vomiting unless told to do so by a Poison Control Center or doctor. Do not give anything to an unconscious person.
IF INHALED: Move person to fresh air. If person is not breathing, call 911 or an ambulance, then give artificial respiration, preferably mouth-to-mouth, if possible. Call a Poison Control Center or doctor for treatment advice.
Note to Physician: Probable mucosal damage may contraindicate the use of gastric lavage.
STORAGE AND DISPOSAL
Do not contaminate water, food or feed by storage or disposal.
PESTICIDE STORAGE: Keep container closed when not in use. Do not store below 0°F for extended periods.
PESTICIDE DISPOSAL: Pesticide wastes are acutely hazardous. Improper disposal of pesticide wastes or rinsate is a violation of Federal law. If these wastes cannot be disposed of by use according to label instructions, contact your State Pesticide or Environmental Control Agency, or the Hazardous Waste representative at the nearest EPA Regional Office for guidance.
CONTAINER DISPOSAL: Non-refillable container. Do not reuse or refill this container. Triple rinse (or equivalent) promptly after emptying. 5 gallon or less containers. Triple rinse as follows: Empty the remaining contents into application equipment or a mix tank and drain for 10 seconds after the flow begins to drip. Fill the container 4 full with water and recap. Shake for 10 seconds. Pour rinsate into application equipment or a mix tank or store rinsate for later use or disposal. Drain for 10 seconds after the flow begins to drip. Repeat this procedure for two more times. Capacity greater than 5 gallon containers. Triple rinse as follows: Empty the remaining contents into application equipment or a mix tank. Fill the container 4 full with water. Replace and tighten closures. Tip container on its side and roll it back and forth, ensuring at least one complete revolution, for 30 seconds. Stand the container on its end and tip it back and forth several times. Turn the container over onto its other end and tip it back and forth several times. Empty the rinsate into application equipment or a mix tank or store rinsate for later use or disposal. Repeat this procedure two more times. Then offer for recycling or reconditioning if available. If not, puncture and dispose of in a sanitary landfill, or incinerate, or, if allowed by State and local authorities, burn container. If burned, stay out of smoke.
Gil Mikro-San 15 Gallon Highlights:
- SKU: 17002
- Manufacturer: Valley Chemical Co
- Toxic chlorine gas will be formed
- Mix only with water following label directions
- Do not mix with chlorinated cleaners or sanitizers
- Contact with soft metals may generate hydrogen gas
- Do not contaminate water, food or feed by storage or disposal
- Usage rate of 1 oz to 6 gal of water provides a low pH, insuring rapid bacterial action while removing water scale and stone buildup
|Manufacturer||Valley Chemical Co.|
|Unit of Measure||each|